机械动力学:2017,Vol:36,Issue(9):1313-1319
引用本文:
梁雪刚, 赵臣, 张佳俊, 刘洋. 计及打滑的履带式核电机器人转向性能分析[J]. 机械科学与技术
Liang Xuegang, Zhao Chen, Zhang Jiajun, Liu Yang. Analysing Steering Performance of Tracked Nuclear Robot based on Skid Condition[J]. Journal Of Remote Sensing

计及打滑的履带式核电机器人转向性能分析
梁雪刚, 赵臣, 张佳俊, 刘洋
天津大学机械工程学院, 天津 300350
摘要:
在基于打滑条件下,履带式机器人两侧履带均匀接地时的转向运动学与动力学研究基础上,推导了在相间分布的外履齿接地时牵引力与转向阻力矩的计算公式,分析了质心偏移的影响,并给出了打滑条件下履带式机器人的转向条件,最后探讨了原地转向时,机器人转向比对滑转率的影响。结果表明:外履齿接地与履带均匀接地时的牵引力和转向阻力矩相同;打滑条件下满足转向条件的转向比范围增大;原地转向时,两侧履带的滑转率随着转向比的增大而增大。
关键词:    履带式机器人    打滑条件    原地转向    质心偏移   
Analysing Steering Performance of Tracked Nuclear Robot based on Skid Condition
Liang Xuegang, Zhao Chen, Zhang Jiajun, Liu Yang
School of Mechanical Engineering, Tianjin University, Tianjin 300350, China
Abstract:
Based on the kinematics and dynamics of a tracked robot under skid condition when its tracks on both sides contact ground evenly, the formulas of traction force and steering resistance moment were derived when the outer grousers contact the ground, and the influence of mass center shift was analyzed. Then the steering condition of the tracked robot under skid condition was obtained. The influence of the steering rate on the skid ratio of pivot steering was discussed. The discussion results show that:the traction force and steering resistance moment are the same when the outer grousers are grounded and the tracks are evenly grounded, the steering rate range that satisfies the steering condition under skid condition increases, the skid ratios on both sides increase with increasing steering ratio when the tracked robot turns.
Key words:    tracked robot    skid condition    pivot steering    mass center shift   
收稿日期: 2016-05-25     修回日期:
DOI: 10.13433/j.cnki.1003-8728.2017.0901
基金项目: 863重大专项预研课题资助
通讯作者: 赵臣(联系人),副教授,博士,zhaochen@tju.edu.cn     Email:zhaochen@tju.edu.cn
作者简介: 梁雪刚(1990-),硕士研究生,研究方向为移动机器人、核电机器人,hbgylxg@163.com
相关功能
PDF(1025KB) Free
打印本文
把本文推荐给朋友
作者相关文章
梁雪刚  在本刊中的所有文章
赵臣  在本刊中的所有文章
张佳俊  在本刊中的所有文章
刘洋  在本刊中的所有文章

参考文献:
[1] 吉洋,霍光青.履带式移动机器人研究现状[J].林业机械与木工设备,2012,40(10):7-10 Ji Y, Huo G Q. Research status of track-type mobile robots[J]. Forestry Machinery & Woodworking Equipment, 2012,40(10):7-10(in Chinese)
[2] Nagatani K, Kiribayashi S, Okada Y, et al. Emergency response to the nuclear accident at the fukushima daiichi nuclear power plants using mobile rescue robots[J]. Journal of Field Robotics, 2013,30(1):44-63
[3] Yamauchi B. PackBot:a versatile platform for military robotics[EB/OL]. (2015-08-31). https://www.deepdyve.com/lp/spie/packbot-a-versatile-platform-for-military-robotics-gPHw4T0JJM
[4] 唐振科.工程机械底盘设计[M].郑州:黄河水利出版社,2004 Tang Z K. Engineering machinery chassis design[M]. Zhengzhou:The Yellow River Water Conservancy Press, 2004(in Chinese)
[5] Wormell P J H, Purdy D J. Handling of tracked vehicles at low speed[J]. Journal of Battlefield Technology, 2004,7(1):21-26
[6] Wong J Y, Chiang C F. A general theory for skid steering of tracked vehicles on firm ground[J]. Proceedings of the Institution of Mechanical Engineers, 2001,215(3):343-355
[7] 迟媛.履带车辆差速转向技术与理论[M].北京:化学工业出版社,2013 Chi Y. Differential steering technology and theory of tracked vehicles[M]. Beijing:Chemical Industry Press, 2013(in Chinese)
[8] 程军伟,高连华,王红岩.基于打滑条件下的履带车辆转向分析[J].机械工程学报,2006,42(S):192-195 Cheng J W, Gao L H, Wang H Y. Steering analysis of tracked vehicles based on skid condition[J]. Chinese Journal of Mechanical Engineering, 2006,42(S):192-195(in Chinese)
[9] 王启广.双履带行走装置转向性能分析[J].矿山机械,1997,(11):27-28 Wang Q G. Turning performance analysis of bi-crawler track[J]. Mining & Processing Equipment, 1997,(11):27-28(in Chinese)
[10] Maclaurin B. A skid steering model with track pad flexibility[J]. Journal of Terramechanics, 2007,44(1):95-110
[11] 杨红旗.工程机械履带-地面附着力矩理论基础[M].北京:机械工业出版社,1990 Yang H Q. Theoretical basis of track ground attachment moment for construction machinery[M]. Beijing:China Machine Press, 1990(in Chinese)
[12] 罗恩志,冯江,张敏,等.基于滑转条件下的履带车辆原地转向特性研究[J].农机化研究,2013,35(2):240-243 Luo E Z, Feng J, Zhang M, et al. Pivot steering characteristics of tracked vehicle based on skid condition[J]. Journal of Agricultural Mechanization Research, 2013,35(2):240-243(in Chinese)
[13] 刘义.RecurDyn多体动力学仿真基础应用与提高[M].北京:电子工业出版社,2013 Liu Y. Application and improvement of RecurDyn multi body dynamics simulation[M]. Beijing:Publishing House of Electronics Industry, 2013(in Chinese)
[14] 焦晓娟,张湝渭,彭斌彬,等.RecurDyn多体系统优化仿真技术[M].北京:清华大学出版社,2010 Jiao X J, Zhang J W, Peng B B, et al. Optimization and simulation technology of RecurDyn multi body system[M]. Beijing:Tsinghua University Press, 2010(in Chinese)
[15] 马星国,陈媛媛,刘兴婷,等.基于多体动力学仿真的履带车辆转向性能分析[J].机械设计,2012,29(6):52-57 Ma X G, Chen Y Y, Liu X T, et al. Steering performance analysis of tracked vehicles based on multi-body dynamics simulation[J]. Journal of Machine Design, 2012,29(6):52-57(in Chinese)